Sunday 12 October 2014

Now for something completely different!!

Douglas DC-3 Dakota G-AMYJ (KN 353) was retired from flying in 1999 by Air Atlantique at Coventry and used as a spares source for the remainder of the fleet. She was acquired by YAM in 2001 as an engine-less shell with the Stb'd outer wing missing.
She arrived on low-loaders and was pieced back together by a small team led by ex-RAF Senior Engineering Warrant Officer George Astley MBE.

G-AMYJ on the dump
The restoration initially was for static display and she was fitted with incorrect ex-Catalina engines and props. The interior was fitted out for 'paratrooping' and the cockpit pieced back together for static display.

As time went on it became clear that it was possible to bring her back to 'life' and two correct Pratt & Whitney Twin Wasp engines were acquired via Air Atlantique as well as flight-worthy propellors. These were installed late in 2009 and a restoration programme was started including a complete rubdown and repaint carried out by myself and Peter Kondras in 2011 into correct RAF Olive Drab colours.

The task to resurrect her was vast, The electrics were in a mess and a number of hydraulic, pneumatic and engine components were missing or U/S.
The team came together for the task and included; George Astley, Graham Sharp, Grant Sparks, Brian Watmough, Bob Emmett, Peter Kondras, Marie Taylor, Ray MacElwain, Ken (radio Ken) Sanderson & Myself. Help came from many outside specialists including; Air Atlantique, CFS Engineering Coventry, Yorkshire Hydraulics, Battle of Britain Memorial Flight & Mark Edwards - DC3 Licensed engineer and pilot on type & 'Paddy' Green - owner of airworthy Dakota N5831B, currently based at East Kirkby in Lincolnshire.

The task was long but the first engine runs were carried out by myself and George in early 2013 and all was progressing well until George's unexpected death in the Summer. This knocked the morale of the team heavily, but we ran the engines for his daughter, and his funeral service (fittingly) was held at the Museum on the same day. We also asked his daughter to unveil the aircraft's new name 'Warrant Officer, George Astley MBE' on the port side of the cockpit just before the funeral service.
One of the first engine runs

Engine runs and restoration continued and finally the decision to taxy her was taken after Bob Emmett had worked his skills on the braking and hydraulic systems.

The day Sunday 12th October was chosen and proved to be very calm, but with heavy fog. However, this gradually lifted and after the Museum's DH Devon had been put through its paces by Steve Pepper and the Devon team it was time for the 'Grand old lady' to steal the show.

As I had carried out all engine runs from the right hand seat, I decided, as I was to taxy her, then I would taxy her from that seat. Graham Sharp was in the left seat with Steve Pepper acting as 'observer' and Bob Emmett monitoring the hydraulics for any leaks or pressure problems.
The crew L to R - Graham, me and Bob

I signaled for chocks away and released the brakes and she immediately rolled forward for a brake check. It was then that I realised I had just moved a WW2 veteran aeroplane under its own power for the first time! I was wearing my Grandfather's RAF Identity Discs 'dogtags' on my flying suit, the last time they were worn in an aircraft was in a Dakota which crashed at Down Ampney at the end of WW2. My Grandfather was one of the lucky ones that escaped the crash, the pilot's sadly did not...
On the runway
After a short roll of about 200 yards I drifted her to the left and with a quick stab of the right hand brake and advancing the left throttle she turned smoothly around on the runway. I taxyed back towards the team and turned her again for a longer run down the runway. We carried out a power-up to 1800 RPM and she wanted to go! I brought the RPM back to a fast idle of 1200 before releasing the brakes. A run of about 1/2 mile followed and it surprised me as increasing either engine RPM by as little as 100 RPM caused 'drift' in either direction. I turned her around and powered the engines up for the watching Fire Team before a brisk taxy back and a final power-up to clean the spark plugs of any oil before shutting her down.



Just after shut down - thumbs up! 
We were all very happy with the results of the day and at no time did I feel frightened of the aircraft, It took a bit of practice to get the feel of her and it'll take quite a bit more to get anything like comfortable with her. She showed that she needs care and demands respect. I have nothing but admiration for the guys who operated them in WW2 and beyond.

Find out more about the DC-3 at http://www.douglasdc3.com

No comments:

Post a Comment